. Clogged intake Remove any obstructions e. All pages are printable, so run off what you need and take it with you into the garage or workshop. Dirty fuel tank Clean the fuel tank. Clogged fuel line Clean or replace the fuel line. Do not scratch the valve seat.
Troubleshooting Trouble Diagnosis Adjustment Hard starting Insufficient fuel Add gasoline. It is fully printable, print 1 page, 1 chapter or print the entire manual and put it in a 3-ring binder. White or gray insulator with small black or grayish brown spots and electrodes having a bluish-burnt appearance Mixture is too lean. Unlike other manuals on the internet my manuals don't need a password to view or print and you can back them up any way you see fit to make sure it's aways there when you need it. Backfiring Dirty carburetors Clean the carburetors. Poor acceleration Slow response to res onse throttle. Fully bookmarked and hyperlinked with a master index for easy use.
Excessive fuel consumption Hard starting Scratched or unevenly worn float valve or valve seat Clean or replace the float valve and valve seat. Air leaking into the carburetor joint. Every Clymer snowmobile service manual contains hundreds of original photographs and illustrations obtained from the complete disassembly and assembly of the snowmobile covered. Keywords: clymer, snowmobile, repair, service, maintenance, manuals, ski-doo, polaris, artic, cat, timing, fuel, injection, water, pump, battery, electrical, wiring, diagrams, engine, yamaha, chilton, ski, doo, vintage, manual, 1984, 1985, 1986, 1987, 1988, 1989, 1990, 1991, 1992, 1993, 1994, 1995, 1996, 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013. Dirty or clogged fuel line Clean or replace the fuel line. Clogged bypass hole Clean the bypass hole. Clogged float valve Disassemble and clean the float valve.
Defective starter valve seat Clean or replace the starter valve seat. Poor performance at Clogged air vent Remove the air vent hose and clean it. Check the cooling system, gasoline octane rating and ignition timing. Arctic cat snowmobile 1990 and earlier performance manual factory 182 page. Overflow Adjust the fuel level. It compensates for the initial wear that occurs during the life of the snowmobile.
Make sure that the pilot jet is fully tightened. The subsequent pages give detailed procedures. Covers complete tear down and rebuild, pictures and part diagrams, torque specs, maintenance, troubleshooting, etc. Includes information on how to do intake, engine, and exhaust modifications to enhance performance. Air leaks into the fuel line Tighten or replace the fuel line joint. This manual provides all service, repair, and maintenance information for your machine.
Melted electrodes and possibly a blistered insulator Metallic deposits on insulator Mixture is too lean. Covers complete tear down and rebuild, pictures and part diagrams, torque specs, maintenance, troubleshooting, etc. The Arctic Cat Snowmobile manual includes the following chapter information: - General info - Troubleshooting - Lubrication - Maintenance and tune-up - High-altitude and rear suspension adjustement - Engine - Fuel and exhaust systems - Electrical system - Oil injection system - Liquid cooling system - Recoil starter - Drive system - Disk brake - Chaincase - Jackshaft and drive axle - Front suspension and steering - Track and rear suspension - Off-season storage - Wiring diagrams The Arctic Cat snowmobile manual by Clymer is the best reference book for repair and service information for your Arctic Cat snowmobile. Fuel passage is clogged or frozen Check and, if necessary, clean the fuel tank air vent, the fuel filter and all of the fuel passages. Overflow: Clogged air vent Clean the air vent. I'll never leave you digging through hundreds or even thousands of pages to find what you need.
Excessive fuel consumption Poor acceleration Clogged or loose main jet. Every Clymer snowmobile service manual is written for the do-it-yourselfer as well as the experienced mechanic, Clymer snowmobile repair manuals are the cheapest way to keep your snowmobile running properly. Throttle Poor acceleration normal speeds: Lean mixture Overhaul the carburetors. Excessive use of the starter or choke Return the starter lever to its seated position so that the starter valve is fully closed. You name it and its in here. Make sure that the pilot jet is fully tightened. Remove the pilot jet, clean it with compressed air, and then install it.
Once you download your manual it is yours forever. Make sure that the main jet is fully tightened. You name it and its in here. Most all service manual chapters start with an assembly or system illustration, diagrams, exploded parts view, quality pictures, service information and troubleshooting for the section. After replacing the spark plug with a colder type, tune the carburetors again.
Clogged fuel filter Replace the fuel filter. Poor idling Poor performance at low, mid-range, high speeds. No one has time to wait for a book or cd in the mail while their vehicle is down and if you're a mechanic your customer definitely doesn't wait a week for the manual to arrive. Covers complete tear down and rebuild, pictures and part diagrams, torque specs, maintenance, troubleshooting, etc. Abnormal combustion: Lean mixture Clean and adjust the carburetors. Clogged or loose main air jet Remove the main jet, clean it with compressed air, and then install it. White or light gray Mixture is too lean.